LUBRICATION ORDER
LO 5-3805-239-12
(Supersedes LO 5-3805-239-12-1, and -2,26 April 1968)
15 DECEMBER 83
LOADER, SCOOP TYPE, PNEUMATIC
TIRED WHEELS, DIESEL ENGINE DRIVEN,
HINGED FRAME STEER WITH 2 1/2 CU YD
MULTIPURPOSE BUCKET (ALLIS CHALMERS
MODEL 645M) (NSN 3805-00-051-9359)
Reference: TM 5-3805-239-12 and FEDERAL SUPPLY CATALOG C9100-IL.
Intervals (on-condition or hard time) and
Clean parts or fittings with dry cleaning
the related man-hour times are based on
solvent (SD), Type II or equivalent. Dry
normal operation. T h e man-hour time
before lubricating. Dotted arrow shafts in-
dicate lubrication on both sides of equip-
specified is the time you need to do all
the services prescribed for a particular in-
ment. A dotted circle indicates a drain
terval. On condition (OC) oil sample inter-
below. Relubricate all items found con-
vals shall be applied unless changed by
taminated after fording or washing.
the Army Oil Analysis Program (AOAP)
laboratory. Change the hard time interval
if your lubricants are contaminated or if
The lowest level of maintenance authoriz-
you are operating the equipment under
ed to lubricate a point is indicated by one
adverse operating conditions, including
of the following symbols as appropriate:
longer-than-usual operating hours. The
O p e r a t o r / C r e w (C); and Organizational
hard time interval may be extended dur-
Maintenance (0).
ing periods of low activity. If extended,
adequate preservation precautions must
be taken. Hard time intervals will be ap-
plied in the event AOAP laboratory sup-
Reporting errors and recommending im-
port is not available.
provements. You can help us improve this
manual. If you find any mistakes, or if you
WARNING
know of a way to improve the procedures,
Dry cleaning fluid is flammable. Do
please let us know. Mail your letter or DA
not use near a flame or excessive
Form 2028 (Recommended Changes to
heat. Use only with adequate ven-
Publications and Blank Forms) direct to:
tilation. Avoid prolonged breathing
Commander, US Army Tank-Automotive
of vapors and minimize skin
C o m m a n d , ATTN: DRSTA-MB, Warren, Ml
contact.
48090. A reply will be furnished to you.
q The time specified is the time required to peform all services
at the particular interval (on-condition or hard times).
q TOTAL MAN-HOURS
q TOTAL MAN-HOURS
INTERVAL
MAN-HOURS
MAN-HOURS
INTERVAL
10
500
0.7
0.2
100
1000
1.3
2.6
250
0.6
TA 219604,
LO 5-3805-239-12
CARD 1 OF 6
