TM 5-3805-292-23
0006
ELECTRICAL TROUBLESHOOTING - EC007 SYSTEM OVER-VOLTAGE/UNDER-VOLTAGE CONTINUED
O
Measure voltage between alternator,
circuit 120C (R) harness side and
24V
Perform Open Harness Test for circuit 120
NO
present?
and 313 (WP 0173).
Starting, & Charging System).
WARNING
CARBON MONOXIDE (EXHAUST GASES) CAN KILL!
Carbon monoxide is a colorless, odorless, deadly poison, which, when breathed, deprives the body of oxygen and causes
o
suffocation. Exposure to air containing carbon monoxide produces symptoms of headache, dizziness, loss of muscular
control, apparent drowsiness, and coma. Permanent brain damage or death can result from severe exposure.
YES
Carbon monoxide occurs in exhaust fumes of internal combustion engines. Carbon monoxide can become dangerously
o
concentrated under conditions of inadequate ventilation. The following precautions must be observed to ensure safety of
personnel when engine of Skid Steer Loader (SSL) is operated.
1.
DO NOT operate engine in enclosed areas.
2.
DO NOT idle engine without adequate ventilation .
3.
BE ALERT for exhaust poisoning symptoms. They are:
-
Headache
-
Dizziness
-
Sleepiness
-
Loss of musculature control
4.
I f you see another person with exhaust poisoning symptoms:
-
Remove person from area
-
Expose to fresh air
-
Keep person warm
-
DO NOT permit physical exercise
-
Administer Cadiopulmonary Resuscitation (CPR), if necessary.
-
Notify a medic.
5.
BE AWARE. The field protective mask for Nuclear, Biological, and Chemical (NBC) protection will not
protect you from carbon monoxide poisoning.
6.
CALI FORNI A PROPOSI TI ON 65 WARNI NG: Engine exhaust and some of its constituents are known
to the State of California to cause cancer, birth defects, and other reproductive harm .
The Best Defense Against Carbon Monoxide Poisoning is Good Ventilation !
Reconnect all previously
disconnected connectors.
Voltage
Run engine at high idle (TM 5-3805-
between
292-10).
Replace alternator (WP 0011).
NO
23.2V and
Measure voltage between alternator,
circuit 120C (R) harness side, and
32.8V?
Starting, & Charging System).
YES
Stop.